MATERIAL & SAFETY
DATA SHEET
SECTION 1 - PRODUCT IDENTIFICATION
|
Product Number |
PX-300 |
|
Product Description |
Vinyl Acetate/Maleate Copolymer with enzymatic wetting agent |
|
SECTION 2 – PHYSICAL AND CHEMICAL PROPERTIES
|
|
Physical State: |
Liquid |
|
Color: |
Milky White |
|
Odor: |
Slight Acrylic |
|
Weight per Gallon |
9.1 lbs. |
|
Specific Gravity: |
1.08 |
|
% Volatile by Weight |
45 |
|
PH: |
5.0 |
|
Vapor Density |
Same as Water |
SECTION 3 – COMPOSITION/INFORMATION ON INGREDIENTS
This Material Safety Data Sheet is prepared to comply with the
United States Occupational Safety and Health Administration (OSHA)
Hazard Communication
Standard (12 CFR 1910.1200) and the Canadian Workplace Hazardous Materials Information
System (WHMIS). Unlisted ingredients are not "hazardous"
per
the OSHA standard and are not found on the WHMIS ingredient disclosure list.
|
Chemical/CAS Number |
Percent |
OSHA PEL |
ACGHI TLV |
|
2-Propenoid Acid, Butyl Ester, Polymer with Ethenyl Acetate
25067-01-0 |
54.5 |
|
|
|
Water 7732-18-5 |
45.5 |
|
|
|
See Section 14 for Additional Information |
|
|
|
SECTION 4 – HAZARDOUS INFORMATION
Emergency Overview: No specific warnings for normal
use conditions
|
Potential Health Effects |
|
Eyes |
Eye contact with liquid product may cause irritation |
|
Skin |
Prolonged/repeated contact with liquid product may cause
irritation |
|
Inhalation |
Not an anticipated route of exposure |
|
Ingestion |
Not an anticipated route of exposure; small amounts not
anticipated to be harmful |
|
Chronic |
No anticipated chronic effects |
|
Related Carcinogen Status |
This product contains no regulated levels of NTP, IARC, ACGIH,
or
OSHA listed carcinogens
|
|
Existing Health Conditions Affected by Exposure |
No known effects on other illnesses |
SECTION 5 – FIRST AID MEASURES
|
In Eye |
Flush immediately with water for 15 minutes, consult
physician if irritation persists |
|
On Skin |
Wash affected area with soap & water, launder
contaminated clothing before reuse |
|
Inhaled Vapors |
Remove subject to fresh air |
|
If ingested |
If able to swallow, drink 1 glass of water or milk. Do not
induce vomiting & get immediate attention. Never give
anything orally to an unconscious person. |
SECTION 6 – FIRE FIGHTING MEASURES
|
Flash Point Method |
Non-flammable |
|
Upper Explosive Limit/Lower Explosive Limit |
Not Applicable |
|
Autoignition Temperature |
Not applicable |
|
Appropriate Extinguishers |
Non-flammable in liquid state; use water, spray, foam, dry
chemical or CO2 if dry. |
|
Special Fire Fighting Procedure |
Persons exposed to product or combustion should wear
self-contained breathing apparatus and wear full protective
equipment |
|
Unusual Fire and Explosive Hazards |
When heated, pressure may build up in closed containers; cool
the containers with water spray |
|
Hazardous Combustion Product |
Incomplete combustion may yield low molecular weight
hydrocarbons , CO |
SECTION 7 – ACCIDENTAL RELEASE MEASURES
Soil/ Leak Procedures: Dike if necessary, contain spill with inert
absorbent and transfer to containers for
disposal. Keep spilled product out of sewers, watersheds or water
systems.
SECTION 8 – HANDLING AND STORAGE
Wear appropriate protective clothing when working with this
product
Avoid temperature extremes in storage; store in ambient
temperatures
SECTION 9 – EXPOSURE CONTROLS/PERSONAL PROTECTION
|
Eye protection |
Safety glasses to avoid prospective eye contact; chemical
safety goggles to avoid splashing; have eye wash facilities if
eye contact is likely |
|
Skin protection |
Rubber gloves and protective clothing to prevent
repeated/prolonged contact; Launder contaiiminated clothing
before reuse |
|
Respiratory Protection |
Not normally required; Use NIOSH/OSHA approved respirators if
required |
|
Ventilation |
General dilution ventilation |
SECTION 10 – STABILITY AND REACTIVITY DATA
|
Stability |
Stable |
|
Incompatibility |
Not established |
|
Hazardous Decomposition |
Not Established |
|
Hazardous Polymerization |
Will not occur |
SECTION 11 – DISPOSAL CONSIDERATIONS
To the best of our knowledge, this product does not meet the
definition of hazardous waste under U.S. EPA
Hazardous Waste Regulations 40 CPF 261. Solidify and dispose of in an
approved landfill. Consult state,
local or provincial authorities for more restrictive requirements.
SECTION 12 – TRANSPORTATION
DOT Proper Shipping Name Not Regulated
SECTION 13 – REGULATORY INFORMATION
|
FEDERAL |
|
Toxic Substances Control Act (SCA)
Section 8(b) - Inventory status |
This product complies with the Toxic Substances Control Act’s
Inventory Requirements |
|
SATA Title III:
Section 313 |
This product does not contain regulated levels of any toxic
chemical subject to the reporting requirements of Section 313 of
Title III of the Superfund Amendments and Reauthorization Act of
1986 (SARA) and 40 CFR, pat 372 |
|
STATE |
|
CA Proposition 65 - The Safe Drinking Water and Toxic
Enforcement Act of 1986 |
This product does not contain chemical(s) known to the State
of California to cause cancer or reproductive damage |
|
INTERNATIONAL |
|
WHMIS Identification/Other International Regulations/WHMIS
Rating |
Not WHMIS controlled
WHMIS Rating
Health: 1
Flammability: 0
Reactivity: 0
Protective Equipment: B
|
SECTION 14 – ADDITIONAL INFORMATION
In storage, monomer vapors will migrate from the emulsion and
establish an equilibrium between the head
space in the storage container and the liquid emulsion. Levels in
excess of acceptable exposures can accumulate in the non-vented head
spaces above the emulsion. All procedures appropriate for a confined space entry should be
completed prior to performing any work on a bulk storage tank.
|
